Zone Offroad J23N Jeep Cherokee XJ lift kit

Be the first to review this product

1984-01 Jeep Cherokee XJ 4.5" lift system Chrysler 8.25, rear springs, Nitro shocks

Product No: J23N ZN

Availability: In stock

FREE SHIPPING Lower 48 States

Important Notes

* To determine rear axle, measure the inside dimension of the rear u-bolts. Chrysler 8.25 u-bolts are 3" and Dana 35 u-bolts are 2-3/4"

Quick Overview

For the Jeep Cherokee XJ 4.5" lift kit, Zone Offroad provides front coil springs designed for offroad use. These coil springs are designed for extreme travel and are so powerful, even when smashed to the bottom they will always come back. They avoid being stiff because of the wire design and spring rate used. These springs are made in the USA. 2" bump stop extensions are supplied to drastically increase wheel travel. This system also includes extended sway bar links to reduce body roll and brake line relocation brackets. Lower control arms made from 1-3/4" x 1/4" thick wall DOM tubing with greasable urethane ends and dual fluting are included to supply the correct alignment as well as axle location. A transfer case drop is also included to correct driveline angle.

The rear is lifted with rear leaf springs designed to give 3" of lift and the max amount of compression travel. This 5-leaf spring pack with anti-friction pads and center leaf spacer plates between each leaf is designed to flatten out as much as possible translating to increased wheel travel without losing the ability to hold up and handle your load of gear. To achieve 4" of rear lift, longer, greasable boomerang shackles have been added to improve articulation while improving the pinion angle. A greasable extended shackle is also supplied to allow the rear leaf springs to really flex. New u-bolts and specially valved Hydro shocks are also included. Shock boots sold separately.

  • Front coil springs designed to give a full 4.5" of lift while maintaining an factory style ride
  • Only 2" bump stop extensions because Zone springs are designed for extreme travel.
  • A minimal (1") transfer case drop to correct the driveline angle while maintaining as much ground clearance as possible.
  • Extended sway bar links with urethane mounts for long term performance
  • Front and Rear brake line relocation brackets
  • Front lower control arms with pre-installed factory like rubber bushings
  • Replacement Rear Leaf Springs
  • Longer Boomerang shackles made to lift the vehicle, correct pinion angle, and improve articulation.
  • Rear U-bolts with high nuts and washers
  • Extended length rear shackles to allow springs to really flex!
  • 4 Nitro shocks

View kit installation instructions

    • Make: Jeep
    • Model: Cherokee XJ
    • Vehicle: 1984-01 Cherokee XJ 4.5" lift system Chrysler 8.25, rear springs, Nitro shocks
    • 2or4: 2WD, 4WD
    • Tire Size: 32x11.50 on 15x8, 4.75" BS
    • Upsell: ZON7400, ZONJ5300, ZONJ5451, PSL920, PSL1100, PSL100


Zone Offroad lift kit fits the following models:
1984 Jeep Cherokee XJ
1985 Jeep Cherokee XJ
1986 Jeep Cherokee XJ
1987 Jeep Cherokee XJ
1988 Jeep Cherokee XJ
1989 Jeep Cherokee XJ
1990 Jeep Cherokee XJ
1991 Jeep Cherokee XJ
1992 Jeep Cherokee XJ
1993 Jeep Cherokee XJ
1994 Jeep Cherokee XJ
1995 Jeep Cherokee XJ
1996 Jeep Cherokee XJ
1997 Jeep Cherokee XJ
1998 Jeep Cherokee XJ
1999 Jeep Cherokee XJ
2000 Jeep Cherokee XJ
2001 Jeep Cherokee XJ

Please wait...